3516E Low Voltage Generator Set
Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.
Generator Set Specifications
- Standby Rating
-
3000 ekW
- Prime Power Rating
-
2725 ekW
- Emissions/Fuel Strategy
-
Tier 2
- Voltage
-
416 to 13,800 Volts
- Frequency
-
60 Hz
- Speed
-
1800 rpm
- Duty Cycle
-
Standby, Mission Critical, Prime
- Maximum Rating
-
3000 ekW
- Minimum Rating
-
2725 ekW
Engine Specifications
- Engine Model
-
3516E, V-16, 4-Stroke, Water-Cooled Diesel
- Bore
-
6.69in
- Stroke
-
8.47in
- Displacement
-
4765in³
- Compression Ratio
-
13.9:1 / 14.3:1
- Aspiration
-
ATAAC
- Fuel System
-
MEUI
- Governor Type
-
Adem™ A5
Generator Set Dimensions
- Length - Maximum
-
304in
- Width - Maximum
-
113in
- Height - Maximum
-
143in
- Dry Weight - Genset (maximum)
-
44930lb
Standard Equipment:
- Air Inlet System
-
- Single element canister type with service indicator
- Air cleaner
- Fuel
-
- Primary fuel filter with integral water separator
- Fuel priming pump
- Generator
-
- IP23 Protection
- Matched to the performance and output characteristics of Cat engines
- Starting/charging
-
- Heavy duty starting system
- Charging alternator
- Control Panel
-
- Over/under voltage (27/59)
- Emergency stop pushbutton
- Speed adjust
- Accessory module data link
- Generator phase sequence
- Panel lights
- Alarm acknowledge
- Generator mounted - rear facing
- kW (per phase, average & percent)
- Engine cool-down timer
- Communications:
- High coolant temperature
- Warning/shutdown with common LED indication of shutdowns for:
- Overcurrent (50/51)
- Amps (per phase & average)
- Oil pressure (psi, kPa or bar)
- Serial annunciator module data link
- 24 Volt DC operation
- Cat ECS controller includes:
- DC volts
- Reverse reactive power (kVAr) (32RV)
- 6 Programmable digital inputs
- 2 Programmable relay outputs (Form C)
- Frequency (Hz)
- Customer data link (Modbus RTU)
- Power factor (per phase & average)
- kW-hr (total)
- Cat ECS 100
- Lamp test
- kVA (per phase, average & percent)
- kVAr-hr (total)
- Coolant temperature
- Text alarm/event descriptions
- Over/under frequency (81 o/u)
- kVAr (per phase, average & percent)
- 4 Programmable relay outputs (Form A)
- Low coolant level
- True RMS AC metering, 3-phase, +/-2% accuracy
- Failure to start (overcrank)
- Operating hours
- Low coolant temperature
- 2 Programmable digital outputs
- Low oil pressure
- Controls:
- Digital indication for:
- Environmental sealed front face
- Overspeed
- Volts (L-L & L-N)
- Reverse power (kW) (32)
- Engine cycle crank
- Programmable protective relaying functions:
- Cooling System
-
- Fan and belt guards
- JWAC
- Radiator fan and fan drive
- Coolant level sensors
- Caterpillar extended life coolant
- Coolant drain line with valve
- Exhaust System
-
- Flanged faced outlet(s)
- Dry exhaust manifold
- Fuel System
-
- Fuel cooler; not included with packages without radiator
- Fuel priming pump
- Secondary fuel filters
- Flexible fuel lines - shipped loose
- Generators And Attachments
-
- Class H insulation, Class F temperature rise at 40C ambient
(105C prime/130C standby)
- NEMA standard hole pattern
- Anti-condensation space heater
- Permanent magnet excitation (PMG)
- Form wound
- 3 Phase brushless, Salient pole
- 6 Lead
- Winding temperature detectors
- Right side extension terminal box, busbar connections, top
mounted, bottom cable entry
- Lube System
-
- Gear type lube oil pump
- Integral lube Oil cooler
- Fumes disposal
- Oil drain lines and valve
- Oil filter, filler and dipstick
- Lubricating oil
- Mounting System
-
- Rubber anti-vibration mounts - shipped loose
- Rails - engine/generator/radiator mounting
- Starting / Charging System
-
- 45 Amp Charging alternator
- Battery and battery rack w/cables
- Battery disconnect switch
- 24 Volt electric starting motor
- General
-
- Right hand servicing
- Paint - Caterpillar yellow with high gloss black rails & radiator
- SAE standard rotation
- Flywheel and flywheel housing-SAE No. 00
Optional Equipment:
- Air Inlet System
-
- Air inlet protection
- Remote air inlet adapters
- Heavy duty air cleaners
- Dual element air cleaners
- Circuit Breakers
-
- 2000, 2500, 3200, 4000 Amp, 4 Pole, IEC rated Circuit breakers
- Circuit breaker harnesses
- Masterpact breaker connections
- P Frame breaker connections
- 2000, 2500, 3200, 4000, 5000 Amp, 3 Pole, IEC rated Circuit breakers
- Busbar connections
- R Frame breaker connections
- Cable entry options
- 1600, 2000, 2500, 3000, 4000, 5000 Amp, 3 Pole, UL-100% rated Circuit breakers
- Optional busbar power connections
- Power Termination
-
- Circuit breakers, IEC compliant
- Control Panel
-
- Voltage raise/lower switch
- PC monitoring (Remote and local)
- Generator temperature monitoring
- Remote speed adjust
- Annunciator modules
- EMCP 4.4
- Vandal proof panel door
- Auxiliary box
- Customer interface options
- Ground
- Language options
- Load share module options
- Mounting group - External box clips
- Cooling System
-
- Optional Serpentine radiators
- Optional ATAAC radiators
- Water level switch gauges
- Expansion tanks
- Exhaust System
-
- Flexible fittings
- Y Adapters
- Elbows
- Mufflers
- Flanges
- Flanges and exhaust fittings
- Fuel System
-
- Duplex fuel filters
- Primary fuel filters
- Generators And Attachments
-
- Differential current transformers - 8.7 and 15 kV class
- Alternator air cleaners
- Instrumentation
-
- Pyrometer and thermocouples
- Lube System
-
- Manual prelube pump
- Electric prelube pumps
- Oil level regulator
- Lube oil in standard sump
- Mounting System
-
- Spring type vibration isolators
- IBC Seismic vibration isolators NORAD
- Puck style low efficiency lsolators
- Power Connections
-
- Neutral ground connections
- 2700 & 3000 Frame
- Grounding groups
- Special Tests / Reports
-
- Fuel consumption test
- Torsional vibration analysis
- Standard engine test charge
- IBC Certifications
- Generator set consumption test
- Generator set test report
- PGS Test report @ 1.0 power factor
- PGS Test report @ 0.8 power factor
- Starting / Charging System
-
- Engine barring group
- 10, 20, 35 and 50 Amp Battery chargers
- Starter cover
- Jacket water heaters
- 24 Volt battery set - Dry
- Electric starting motors
- Air starting motors
- Air pressure regulator
- General
-
- US aid emblem
- Special paint colors
